Product ID:395FD CURE, AMERCOAT
MSDS Date:11/08/1991
FSC:8010
NIIN:00N028530
Kit Part:Y
MSDS Number: BMYBS

AMERON PROTECTIVE COATINGS

201 NORTH BERRY ST
BREA, CA 92622-1020
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-529-1951

Preparer: H. KLINE

Cage: 0Y2E4

AMERON PROTECTIVE COATINGS

1020 BREA, CA 92622-1020 US

Telephone: 714-529-1951

Cage: 0Y2E4

ETHYLENEDIAMINE/METHYL ISOBUTYL KETONE KETIMINE; (ALIPHATIC

CAS: 25707-70-4

Fraction By Weight: <80%

(ORAL RAT)1.6 G/KG.

RTECS: 9999999ZZ

(ORAL RAT)3.2 G/KG.

CAS: 7631-86-9

RTECS: VV3100000

Fraction By Weight: <15%

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

(ORAL

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 9.35%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

10.7 @

CAS: 107-15-3

RTECS: KH8575000

Fraction By Weight: <5%

OSHA PEL 10 PPM

ACGIH TLV: 10 PPM, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:SEE ING
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:VAP/SPRAY MIST AND/OR DUST CAN BE
HARMFUL. IRRIT TO SKIN, MUCOUS MEMBRANES, EYES & RESP SYSTEM.
EXCESSIVE INHAL CAN CAUSE HEADACHE, NAUSEA, DIZZINESS/ASPHY.
RPTD/PRLNGD OCCUPATIONAL OVEREXPOS TO SOLV IS ASSOC W/PERMANENT
BRAIN & NERVOUS SYS DMG. CAN BE HARMFUL IF SWALLOWED. CAN BE
HARMFUL IF (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INHALED/ABSORBED THROUGH SKIN.
OVEREXPOS CAN DMG LUNGS, CNS. OVEREXPOS CAN CAUSE IRREVERSIBLE EYE
BURNS AND DAMAGE. SKIN AND RESPIRATORY SENSITIZATION AND ALLERGIC
REACTION CAN OCCUR SUCH AS RASH, HIVES/ASTHMA.
Medical Cond Aggravated by Exposure:RESPIRATORY. ALLERGIES. SKIN.

First Aid:INHAL:PROVIDE FRESH AIR; IF BREATHING LABORED, GIVE
OXYGEN/ARTIFICIAL RESPIRATION. SKIN:WASH THROUGHLY WITH SOAP AND
WATER. EYES:FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MD ATTENTION. INGEST:DRINK 1 OR 2 GLASSES OF WATER
TO DILUTE. DO NOT INDUCE VOMITING. CONSULT MD OR POISON CONTROL
CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.

Flash Point Method:SCC
Flash Point:109F,43C
Lower Limits:1.00%
Upper Limits:14.40%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT,
SPARKS & OPEN FLAME.

Spill Release Procedures:AVOID BREATHING VAPORS OR DUST. USE ABSORBENT
MATERIALS OR SWEEP UP. PLACE IN SEPERATE CONTAINER. KEEP OUT OF
SEWERS AND WATERWAYS. IF ENTRY IS THREATENED OR OCCURS, NOTIFY
LOCAL AUTHORITIES. ELIMINAT E ALL SOURCES OF IGNITION.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID STORAGE
TEMERATURES ABOVE 100F.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PRLNGD BRTHG OF DUST,
VAP/SPRAY MIST/CONTACT W/SKIN & EYES. DO NOT WELD/FLAME CUT AN
EMPTY CONTR. GROUND CONTRS WHEN POURING. DESTROY CONTAM LEATHER &
ABSORB SHOES WHICH CANNOT BE DECONTAMINATED.

Respiratory Protection:NIOSH/MSHA APPRVD RESP. FOR SPEC CONDTNS REFER
TO NIOSH POCKET GUIDE TO CHEM HAZ, DHEW NO 78-210. USE AIR-LINE
RESP IN CONFINED/RESTICT VENT AREAS/W/POLYURETHANE/ISOCYANATES.
REFER TO 29CFR OSHA PART 1910, 1915 & 1916 FOR COATING OPERATIONS
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM CINC BELOW TLV LIM. REMOVE WELDING/ (SUPDAT)
Protective Gloves:NEOPRENE OR OTHER SUITABLE MATERIAL
Eye Protection:CHEM WORK GOGG/FULL LENGTH FCSHLD.
Other Protective Equipment:FULL PROTECTIVE CLOTHING. SPARK-PROOF
EQUIPMENT. EMERGENCY EYE WASH AND DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY BEFORE EATING, SMOKING OR USING
WASHROOM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EVAP RATE:LOW:0.40 HIGH:0.70 (BU AC = 1). VENT:FLAME CUTTING
DECOMPOSTION PRODUCTS. REFER TO 29 CFR, OSHA PARTS 1910, 1915 AND
1916 FOR COATING OPERATIONS.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:0.91
Evaporation Rate & Reference:SUPDAT
Appearance and Odor:LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:72

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARC OR SPARKS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING:CO, CO2,
NOX.

Waste Disposal Methods:IN SEPERATE, CLOSED METAL CONTAINER IN
ACCORDANCE WITH ALL APPLICABLE REGULATIONS. DISPOSAL MUST BE IN
ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS . EPA WASTE #
D001 D002

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.